Hyundai Elantra

since 2000-2004 of release

Repair and car operation



Elantr's Hyundai
+ Petrol engines 1,6, 1,8 and 2,0 of l
+ Diesel engine of 2,0 l
+ greasing System
+ cooling System
+ Fuel system
+ Monitoring systems and decrease in toxicity of the fulfilled gases
+ ignition System
+ System of preliminary heating of the diesel engine
+ Coupling
+ Mechanical transmission
+ Automatic transmission
+ Power shafts, forward and back axes
+ Suspension bracket
+ Steering
+ Brake system
+ Body
+ air Central air
- Electric equipment
   Specifications
   Charging system
   Generator
   Power failure check on a wire connecting the storage battery to the generator
   Check of the current developed by the generator
   Check of developed tension
   Generator of petrol engines
   Generator of the diesel engine
   Storage battery
   Start system
   Starter of petrol engines
   Starter of the diesel engine
   Safety locks
   Block of safety locks
   Multipurpose switch
   Sound signal
   Combination of devices
   Switch of position of the parking brake
   Screen wiper and stekloomyvatel of a windscreen
   Screen wiper of back glass
   Headlights and forward indexes of turn
   Forward fog lights and turn repeaters
   The back combined lamp
   Top stoplight
   Lamp of illumination of registration plate
   The ceiling lamp (with the hatch)
   The ceiling lamp (without the hatch)
   Lamp of illumination of salon
   Check of the relay of headlights
   Radio receiver
   Heater of back glass
   Safety cushions (SRS)
   Seat belts
   Search and elimination of malfunctions
   Specification for adjustments and control
Electric circuits




Electric equipment

Specifications

Storage battery

Type
MF 45 of Ach
MF 60 of Ach
MF 68 of Ach
Ampere hours (5HR)
More than 36 Ach
More than 48 Ach
More than 54 Ach
Current at a provorachivaniye of a cranked shaft of not heated-up engine
380 And
550 And
600 And
Reserve capacity
80 mines
92 mines
110 mines
Electrolit density at temperature 25°С, g/cm3
1,280±0,01
1,280±0,01
1,280±0,01

The current at a provorachivaniye of a cranked shaft of not heated-up engine is a current which the storage battery during 30 can give with, thus support tension not below 7,2 Century.

The reserve capacity is time during which the storage battery can 26,7°С give at temperature a current 25 And, thus support tension not below 10,5 Century.

Starter

Name
Petrol engines
Diesel engine
Type
With planetary transfer
With planetary transfer
Tension
12 In
12 In
Rated power
1,2 kW
2,0 kW
Idling characteristics
Limiting tension
11 In
11,5 In
Consumed current
No more than 90 And
No more than 100 And
Frequency of rotation
2800 mines–1
4000 mines–1
Quantity of teeths of a gear wheel
8
9
Gear wheel gap
0,5–2 mm
0,5–2 mm

Generator

Name
Petrol engines
Diesel engine
Rated power
13,5 In / 90 A
12 In / 120 A
Type of a regulator of tension
The electronic built in
The electronic built in
Tension of a regulator
14,4±0,3 In
14,7±0,3 In
Temperature compensation
– 10±3 мВ/°C
– 10±3 мВ/°C

Control and precautionary lamps

Lamps
Capacity, W
Color
Illumination lamps
3,4/LED
it is yellow the green / blue
Driving beam
3,4/LED
the blue
Low level of fuel
3,0/LED
the amber
Turn signal
1,4/LED
the green
Charging of the storage battery
1,4/LED
the red
Pressure of oil
1,4/LED
the red
Safety cushion
1,4/LED
the red
Parking brake
1,4/LED
the red
Seat belt
1,4/LED
the red
Control of work of systems of the engine
1,4/LED
the amber
ABS
1,4/LED
the amber
Open door
1,4/LED
the red
The trunk lid is open
1,4/LED
the red
Cruise control
1,4/LED
the green
Fog lights
1,4/LED
the green
Immobilizer
1,4/LED
the amber
TCS
1,4/LED
the amber
The O/D switch – a mode of an automatic transmission
1,4/LED
the amber
Glow plugs (Diesel engine)
1,4/LED
the amber
Water separator (Diesel engine)
1,4/LED
the amber
Vacuum amplifier of brakes (Diesel engine)
1,4/LED
the red
Automatic transmission
R
1,4/LED
the green
N
1,4/LED
the amber
D
1,4/LED
the green
2
1,4/LED
the green
3
1,4/LED
the green
L
1,4/LED
the green

Temperature index

Temperature
Corner, °
60°С
0
85–110
38
Red sector (more 125°С)
87±5

Lamps of system of lighting

Lamps
Capacity, W
Headlight
55/55
Forward signal of turn
21
Forward dimensional lighting
5
Forward fog lights
55
Back lamps:

– back dimensional osv./stoplights

5/21

– backing

21

– turn signal

21
Back antifog lamps
21
Lateral repeater of turn
5
Internal lighting
10
Top stoplight
21
Lighting in the car salon, joining when opening door
5
Illumination of registration plate
5

Speedometer

Data
Value
Speed, km/h
20
40
60
80
100
Admission, km/h
20–24,4
40–43
60–64,4
80–85,5
100–105,2
Speed, km/h
120
140
160
180
200
Admission, km/h
120,5-126
140,5–146
160,5–166
181–186,5
201–206,5

Tachometer

Data
Value
Frequency, mines–1
1000
2000
3000
4000
5000
6000
Admission, mines–1
±100
±125
±150
±170
±200
±240

Index of level of fuel

Level
Index
The admission with the fuel level sensor
Resistance, Ohm
E (Empty)
97
0±2,5
1/2
32,5
4 ±5,0
F (Full)
6
90±2,5

Cleaner and windscreen washer

Name
Technical requirements
Engine of a screen wiper of a windscreen
Speed/current, 1,0 N • m
Slowly: 44–52 mines-1/no more than 3,5 And
Quickly: 66–80 mines-1/no more than 4,5 And
Speed/current, 3,9 N • m
Slowly: 39–47 mines-1/of no more than 7 And
Quickly: 57–69 mines-1/of no more than 9 And
Current when blocking
Slowly: no more than 24 And
Quickly: no more than 28 And
Engine of a screen wiper of back glass
Speed/current, without loading
48 mines-1/no more than 2,0 And
Speed/current, 1,0 N • m
34–46 mines-1/no more than 3,5 And
Current when blocking
no more than 9 And
Angle of rotation without loading
90 °±3 °
Productivity of the pump of a washer, cm3/mines
1500
The pressure created by the pump, kg/cm2
1,6
Uninterrupted operation
With water
60
Without water
20

Moments of an inhaling, N • m

Data
Value
Plug (B +) generator
5–7
Plug (B +) starter
10–12
Plugs of the storage battery
4–6
Spark plug
20–30
Glow plug
15–20
Nut of fastening of the tire of a glow plug
1–1,5

General information

The system of electric equipment of negative grounding has working tension of 12 volts. A food for system of electric equipment arrives from the lead-acid accumulator which is recharged from the generator.

It is necessary to notice that at work with any element of electric equipment of the car the wire of the negative plug of the accumulator should be disconnected for prevention of short circuit and/or ignition.

Through regular intervals check an arrangement and fastenings of wires, watch that wires did not fray about other elements. If you find out that any wires rub about other elements, take wires aside and fix them so that it did not repeat.

Precautionary measures

It is forbidden to change polarity of a food of various devices and devices of the electric equipment in order to avoid failure of semi-conductor devices.

It is forbidden to disconnect and attach the storage battery, measuring devices and any wires on the working engine.

It is forbidden to check serviceability of the generator short circuit on mass of a power conclusion.